utilization of lf slag

Hot Searches

OPTIMISATION OF THE SLAG MODE IN THE LADLE DURING ,

The process of forming ladle slag within secondary metallurgy depends on the quantity of the used slag-making agents (CaO and the fluxing agents , During the treatment of the steel in the secondary-metallurgy units (HS and LF), the samples of the steel and slag were taken at the following technological pla-ces: in the ladle after tapping them ....

Dissolution of multicomponents during hydrothermal ,

Dissolution of multicomponents during hydrothermal leaching of LF desulfurization slag HE Huan- yu 1,2 ,WANG Jie- qi 1,2 ,ZHANG Hua 1,2 ,SONG Ze- yu 1,2 ,HOU Wei- wei 1,2 1The State Key Laboratory of Refractories and Metallurgy, Wuhan University of Science and Technology, Wuhan 430081, Hubei, China...

Cyclic Use of Ladle Furnace Refining Slag for Desulfurization

The low use of recycled LF slag can be attributed in part to the steel industry slag classification, which does not specify when the waste slag can be recycled Also instability and uncertainty in the availability of slag composition are two of the main factors that lead to such a low utilization rate...

Common Uses for Slag | National Slag Association

Slag is a product of the steel making process Once scorned as a useless byproduct, it is now accepted and, often, preferred and specified as it is known to be a valuable material with many and varied us...

Optimization of Steel Production: Ladle Furnace Slag and ,

A slag optimization model is the first objective of this thesis The importance of slag has been very well understood by the steelmaking industry to produce cost effective, quality...

Use of Al-Killed Ladle Furnace Slag in Si-Killed Steel ,

Use of Al-Killed Ladle Furnace Slag in Si-Killed Steel Process to Reduce Lime Consumption, Improve Slag Fluidity...

Utilization of Ladle Furnace slag from a steelwork for ,

European research on the recovery and use of LF refining waste slag has been ongoing for a period of time [8][9][10] Many scholars are concerned by LF slag recycling under cold conditions using ....

Using Steel slag in infrastructure development - FICCI blog

In contrast with other nations, most slag produced in India, especially steel slag, is discarded, however, this is increasingly becoming a problem due to paucity of land; utilization of slag is in the trial phase...

3 Iron Unit Recycling - Department of Energy

3 Iron Unit Recycling On a weight basis, steel is the most recycled material in use today (Figure 3-1) The 70 million net tons of steel recycled in 2000 were used to produce about 112 million net tons of new steel in the United Stat...

EVALUATION OF STEEL DESULPHURIZATION IN THE LADLE ,

the separate slag components, modifications with the help of slag-making additions with the aim of achieving an optimal chemical composition of the slag and the...

9--Application and Breakthrough of BOF Slag Modification ,

Due to the existence of f-CaO in slag, the volume of slag expands during hydration, limiting the uses of BOF slag Accordingly, removing f-CaO to prevent BOF slag from expansion is the key for slag utilization...

Etimine USA, Inc

product throughout slag 3) When this product is added to LF, does slag convert immediately to a thicker state? Is there any effect on slag fluidity after casting molten metal? If it is so, then it will be very difficult to deslag of ladle after casting , Etimine USA, Inc...

Slag Composition Control for the Re-Utilization of LF Hot ,

Slag Composition Control for the Re-Utilization of LF Hot Steel Slag: PENG Qing-liang 1,TANG Ping 1,WEN Guang-hua 1,LIU Bing-yu 2,LI Ju-zhong 2: 1 College of Materials Science and Engineering, Chongqing University, Chongqing 400044, China...

Slag - definition of slag by The Free Dictionary

Core services include slag handling utilizing slag pot carriers or the traditional slag pit digging with front-end loaders; the recovery and sizing of scrap metal to its customer's specification; and processing slag for use by its steel mill customer or marketing processed slag material for aggregate use...

Utilization of Industrial Waste Slag as Aggregate in ,

The carbonated LF slag shown in Table 2 was used as a fine aggregate in zero-slump press-formed Table 3 is providing mix proportions details for con- compact mortar samples and compare to similar samples trol mixes (without replacements with slag) containing control river sand...

Effect of TiO2 addition to LF refining slag on the Ti, Al ,

The influence of TiO 2 addition to LF refining slag on Ti-stabilized stainless steel was evaluated using a vacuum induction furnace at 1873 K The effect of CaO-SiO 2-MgO-Al 2 O 3 basic slags with different TiO 2 contents on the titanium loss, aluminum loss and total oxygen content in the steel was studied...

LF Slag Rubi - Borderlands 2 Message Board for Xbox 360 ,

For Borderlands 2 on the Xbox 360, a GameFAQs message board topic titled "LF Slag Rubi"...

Center for By-Products Utilization

Center for By-Products Utilization LIMESTONE POWDER USE IN CEMENT AND CONCRETE By Tarun R Naik, Fethullah Canpolat, and Yoon-moon , slag, limestone and silicious stone for part of fine aggregate in concrete and the , tested at 1, 3, 7, 28 and 90 days They also demonstrated that the use of ternary blended cements (PC-LF-BFS) provides ....

An Overview of Utilization of Steel Slag - ScienceDirect

The current utilization rate of steel slag is only 22% in china, far behind the developed countri At present, the amount of slag deposited in storage yard adds up to 30Mt, leading to the occupation of farm land and serious pollution to the environment...

IN MEMORIAM Prof Dr Ing PETRU BALTĂ O NOUĂ ,

LF slag (slag from secondary treatment of steel) occurs in the form of a powdery material By using these slags in improving of acid soils seeks the calcium oxide high basicity from the slag, so this type of slags can be an active amendment in acidic soil treatment technologi...

Recovery and utilization of oxides in steel slag of LF ,

LF refining furnace slag and metallurgical production of the main components of the raw materials used in similar components, the LF refining furnace slag in the metallurgical production of resources in the re-use, can greatly improve the utilization of LF refining furnace slag, saving metallurgical raw materials...

CN105838846A - Method for controlling basicity of LF ,

The invention discloses a method for controlling the basicity of LF refining slag The method comprises the steps of 1, making a steel ladle enter an argon blowing position for measuring the height of the slag of the steel ladle after tapping is completed; 2, adding lime and fluorite into the refining slag for slag formation after the argon blowing operation and the temperature measurement ....

SLAG; VALUE ADDED STEEL INDUSTRY BYPRODUCTS ŻUŻEL; ,

The history of slag use in road building dates back to the time of Roman empire, some 2000 years ago, when broken slag from , Recycling of LF slag in EAF charge Fixation (sequestration) of CO2 by producing car-bonates from steelmaking slag Glass production Construction til ,...

Lf Slag In Sinter - belgian-pressbe

1 Aug 2013 A promising type of steel slag for applications is the ladle furnace (LF) slag, is an adsorbent with selectivity, high adsorption capacity, ....

Technologies of steel slag treatment and comprehensive ,

According to the present situation of steel slag treatment,some technologies of steel slag treatment and comprehensive utilization of resouces are reviewed in this paperThe steel slag treatment technologies include: hot water splash,air quenched,water quenched,roller processing,etcThe technologies of comprehensive utilization of resouces include:using steel slag as smelting ,...

Accelerated ageing of LD slag Comparison of water ,

- the slag pit area offers a sufficient number of pouring sections in order to receive 2 or 3 different classes of slag; - the control of the weathered slags is effectuated by use of an equipment for measuring its expansion under the action of water steam (FEhS method)...

CHARACTERIZATION OF LADLE FURNACE SLAG FROM THE ,

In order to make a complete characterization of ladle furnace slag (LF slag, LFS), as nonhazardous industrial waste, and to solve its permanent disposal and/or recovery, bearing in mind both the volumes formed in the Croatian steel industry and experiences of developed industrial countries, a study of its properties was ....

Characterization of Ladle Furnace Slag from Carbon Steel ,

The LF slag is a byproduct from further refining molten steel after coming out of a basic oxygen furnace (BOF) or an electric arc furnace (EAF) The use of the LF slag in further applications requires knowledge of its characteristics...

Etimine USA, Inc

product makes LF slag slightly more fluid because it lowers the melting temperature of slag slightly The slag will not be converted immediately to a thicker state...

USE OF LADLE FURNACE SLAG FROM AL-KILLED STEEL IN SI ,

Nov 17, 2016· At this point, the liquid slag in the slag pot comprised EAF slag (˜30% FeO) at the bottom and Al-killed ladle slag (˜1-2% FeO) at the top To avoid mixing of EAF slag and Al-killed ladle slag, the top liquid slag can be dumped at one location and the bottom solid portion at an adjacent but separate location...